Product ID:F-165B ORANGE MIL-P-24441 F-09P60
MSDS Date:11/29/1994
FSC:8010
NIIN:00N064001
Kit Part:Y
MSDS Number: BZLXD

SEAGRAVE COATINGS CORP OF VA

4030 SEAGUARD AVE
PORTSMOUTH, VA 23701
US

Emergency Phone: 804-488-4411

Info Phone: 804-488-4411

Preparer: SDD

Cage: 60163

SHERWIN-WILLIAMS, SEAGUARD

PORTSMOUTH, VA 23704 US

Telephone: 757-397-2223

Cage: 60163

TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (MAGNESIUM

CAS: 14807-96-6

RTECS: WW2710000

Fraction By Weight: 15%

OSHA PEL 20 MPPCF Z-3

ACGIH TLV: 2 MG/M3 RDUST

SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (SUPER

CAS: 64742-95-6

RTECS: WF3400000

Fraction By Weight: 20%

OSHA PEL N/K

ACGIH TLV: 100 PPM (MFR)

0.0 @ 20C

CAS: 25085-99-8

Fraction By Weight: 60%

OSHA PEL N/K

ACGIH TLV: N/K

249 (GR/LTR)

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:BREATHING OF HIGH VAPOR CONCENTRATONS
MAY PRODUCE NARCOSIS. LIQUID MAY CAUSE MINOR SKIN IRRITATION AND
DEFINITE EYE IRRITATION. CAUSES EYE IRRITATION. CAUSES SKIN
IRRITATION. RPTD AND PRLNGD OVEREXP T O SOLVS COULD CAUSE PERM
BRAIN & NERV SYS DMG. INTENTIONAL MISUSE BY DELIB CONC & INHAL
CONTENTS MAY BE HARMFUL/FATAL.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHALATION:REMOVE TO FRESH AIR, RESTORE BREATHING. CONSULT A
PHYSICIAN. SKIN:FLUSH WITH WATER. WASH THOROUGHLY WITH SOAP AND
WATER. EYES:FLUSH IMMEDIATELY WITH PLENTY OF WATER FOR AT LEAST 15
MINUTES AND GET IMMEDIATE MEDICAL ATTENTION. INGESTION:GET MEDICAL
ATTENTION IMMEDIATELY.

Flash Point Method:SCC
Flash Point:100F,38C
Lower Limits:1.0%
Upper Limits:10.0%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . WATER MAY BE USED TO COOL CONTAINERS. IF
WATER IS USED FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. VAPS MAY
MIGRATE TO IGNIT SOURCE & CAUSE FLASH FIRE. ISOLATE FROM HEAT,
SPKS, ELEC EQUIP, APPLIANCES, PILOT LIGHTS, FLAMES & (SUPDAT)

Spill Release Procedures:IN CASE OF SPILLAGE ABSORB WITH INERT MATERIAL
AND DISPOSE OF IN ACCORDANCE WITH APPLICABLE REGULATIONS OF E.P.A.
AND OTHER LOCAL, STATE AND FEDERAL AUTHORITIES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE AWAY FROM HEAT, SPKS & OPEN
FLAME. AVOID PRLNGD SKIN CONT. DO NOT BRTH SPRAY MIST. AVOID CONT
W/EYES, SKIN & CLTHG.
Other Precautions:STORE IN COOL, DRY AREA W/VENT SUITABLE FOR STORING
MATLS IN INGS. GROUND CNTNRS WHILE POURING. AVOID SPONTANEOUS
COMBUST OF CONTAM RAGS/OTHER ORG MATLS. EMPTY CNTNRS MAY RETAIN HAZ
PROPERTIES & CAN B E DANGEROUS.

Respiratory Protection:NIOSH/MSHA/OSHA APPRVD RESP TYPES SUITABLE FOR
MATLS IN INGS REC. NIOSH/MSHA APPRVD CHEM/MECH FILTERS REC WHEN
VENT IS RESTRICTED. DO NOT BRTHE (DUST, VAPS/SPRAY MIST). WEAR
APPROP RESP (NIOSH/MSHA AP PRVD) DURING & AFTER APPLICATN (SUPDAT)
Ventilation:SUFFICIENT VENT, IN VOL & PATTERN, SHOULD BE PROVIDED TO
KEEP AIR CONTAM BELOW CURRENT APPLIC OSHA PEL/ACGIH'S (SUP DAT)
Protective Gloves:CHEMICAL RESISTANT PLASTIC OR RUBBER.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS(SUPDAT)
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
AS REQ TO AVOID WETTING CLTHG. USE PROT CREAMS WHERE SKIN (SUPP
DATA)
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE AND WASH
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
EXPLO HAZS:OTHER SOURCES OF IGNIT. COMBUST LIQ & VAP. RESP PROT:UNLESS
AIR MONITORING RECORDS VAP/MIST LEVELS BELOW APPLIC LIMS. FOLLOW
RESP MFR DIRECTIONS FOR USE. VENT:TLV LIM. USE W/ADEQ VENT. EYE
PROT:& FULL LENGTH FACE SHIELD . OTHER PROT EQUIP:CONTACT IS
LIKELY.

Boiling Pt:B.P. Text:>308F,>153C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:LIQUID WITH A SOLVENT ODOR.
Percent Volatiles by Volume:28.8

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS, OR OPEN FLAME.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.

Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. DISPOSE OF PRODUCT
IN ACCORDANCE WITH LOCAL, COUNTY, STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.